Precision Electrical Measurement Using Delphin
Motor Test stands are required during the automotive R&D phase for serial testing and also for endurance trials. Measurements taken during the developmental phase such as Temperature and Voltage are fully-automated whenever possible. Sensors check the electrical and mechanical properties of the test sample as well as temperature patterns and overload operation. Testing conditions can vary widely--from the tiniest of motors to large drives in the megawatt range--and need to be adapted to customer requirements.
• Easy-to-use, automated testing procedures
• Test sample conditioning management, voltage supply, frequency converters, and switch matrixes
• Time-synchronized temperatures, pressures, rotations, electrical measurements and torques
• Precision electrical measurement via power measurement units
• Online monitoring of threshold values during the testing procedure
In an example engine test system, technicians are testing explosion-protected motors during their developmental stage at five independent stations. A single test procedure can comprise multiple, mainly automated, sub-tests. ProfiMessage devices record data, manage the test stands, and are responsible for all test-voltage management.
Delphin Message hardware controls all relay matrixes and frequency converters as well as all air-conditioning requirements. The devices exchange information directly with each other and require no PC support. Secure and problem-free processing is assured through control redundancy.
Typical Areas of Application:
• Cold-resistance measurement and extrapolation of winding resistances
• Non-load testing
• Rated load testing
• Load curves testing
• Overload trials
• Locked rotor testing
• Torque-speed characteristic curve
• Testing of voltage series
• Determination of efficiency
• Heat testing
ProfiMessage Data Acquisition & Control System:
ProfiMessage systems have been developed for use as modular measurement, control and monitoring units. They have been used successfully in the fields of process technology, test engineering, and research and development. ProfiMessage devices process any signal quickly and reliably from just a few thermocouples right up to thousands of measurement points spread over several plant areas.
LogMessage Data Acquisition Systems:
LogMessage Data Loggers are an advanced high-speed data logger for demanding applications. They are suitable for stand-alone data logging, product testing, quality and reliability testing, process monitoring, R&D, and fault analysis. Virtual internal channels allow calculations, statistics, and various other functions.
TopMessage Data Acquisition & Control System:
TopMessage systems are used worldwide in many different data logging, data acquisition and testing applications. I/O modules are available for any number of channels and sensor types. A network interface enables TopMessage devices to be integrated into a TCP network or to be directly connected to a PC workstation or laptop computer. Online measurement data can be transmitted, saved and processed. The data can be stored simultaneously within the TopMessage device itself.
For more information on Delphin Message devices, or to find the ideal solution for your application-specific needs, contact a CAS Data Logger Applications Specialist at (800) 956-4437 or visit our website at www.DataLoggerInc.com.
Computer Aided Solutions, LLC. dba CAS Data Loggers is a distributor of data loggers, paperless recorders and data acquisition equipment.
CAS DataLoggers, Inc.
8437 Mayfield Rd.
Chesterland, Ohio 44026
This release was published on openPR.
Permanent link to this press release:
Please set a link in the press area of your homepage to this press release on openPR. openPR disclaims liability for any content contained in this release.
You can edit or delete your press release Precision Electrical Measurement Using Delphin here
News-ID: 354924 • Views: 409
More Releases from CAS DataLoggers
CAS Reaches Over 600 COVID-19 Vaccine Monitoring Kits Shipped!
Since the rollout of COVID-19 Pfizer and Moderna vaccines at the end of December 2020, CAS has been hard at work meeting the demand for vaccine temperature monitoring kits. This demand has only increased with the addition of the Janssen/Johnson & Johnson vaccine and the expansion of vaccines available to the general public in the United States. As of Monday, March 15th, 2021, CAS has now shipped over 600 COVID-19
New Wireless IoT ProfiSens Series from Infinite Informatics
New ProfiSens Wireless IoT Series from Infinite Informatics CAS DataLoggers is pleased to introduce the new AERINOS ProfiSens wireless IoT series from Infinite Informatics. The series includes a family of wireless sensor nodes and a cellular Data Gateway which forwards data and sends SMS alarm messages. Using ProfiSens, you can deploy anywhere using your own IoT network. The ProfiSens series includes the following components: ADU-700: Low power data concentrator with a cellular modem ADS-101:
New NXprog Programmable I/O Module from Novus
We are pleased to announce the new DigiRail NXprog from Novus Automation. The NXprog unites the best of both worlds: the reliability and robustness of an industrial device for automation applications with the ease of programming from the Arduino community. It provides a rich mix of integrated analog and digital I/O signals, allowing DigiRail NXprog to be used as an extension of standard data logging, data acquisition, and automation systems,
New Simple Logger Series of Data Loggers from AEMC
CAS Dataloggers is pleased to announce the new Simple Logger® series of data loggers from AEMC. The SL family includes ten different small, one channel recording devices powered by two AA alkaline batteries. Models are available for recording AC voltage, DC voltage, DC current, temperature, or digital pulses and events. The simple logger series are extremely easy to configure with just a few parameters to setup – scaling, measurement units,
More Releases for Message
Message 2 Millions Ted McGrath
Message 2 Millions Is coming this August 2017, Ideal for Coaches, Speakers,Professionals, Artists & everybody in general.Ted McGrath shares his experience. So what would You get in Message to Millions 2.0 and who is Message 2 Millions for? Message 2 Millions is the most comprehensive coaching program in the industry. Ted McGrath who has devised message 2 millions is one of the highest paid consultants in this industry. Today Ted gets
MOL President Muto’s 2013 New Year Message
"Heaven Helps Those Who Help Themselves.” I would like to take this opportunity to wish all MOL Group members a Happy New Year. 2013 is the Year of the Snake in the Japanese zodiac. The snake is supposed to bring good economic fortune as a symbol of wealth and prosperity. Since I was born in the year of the snake, I hope to bring in some of this good fortune. This year,
Fumes: A message for the future, launched
The Future Message application was launched today by Xminds Infotech Pvt. Ltd. The Future Message application is available @ http://www.fumes.me The Future Message or Fumes in short, is a free service which stores your email, and delivers to the recipient at the requested time & date in the future. Fumes can remind you of an upcoming dental appointment or you can even write a letter to yourself
IGM Offers Worldwide SWIFT Message Services
Interlink Global Messaging offers worldwide SWIFT messaging services for banks, financial institutions, securities broker dealers, and more. Walnut Creek, CA – Interlink Global Messaging (igmswift.com/), a leading SWIFT message service provider, offers SWIFT network resources for a variety of financial institutions worldwide. IGM’s services offer financial institutions the ability to connect and exchange financial information securely over the SWIFT network. This enables financial companies to offer a wider range of services
Mail Me Art: Medium Without a Message
An exhibition of Mail Art with an amazing collection of envelopes and boxes from around the world decorated by some of today's most talented illustrators and artists Exhibition Opens: Friday 30th of July 2010 – 6.00 pm to 11.00 pm (All Welcome!) Exhibition runs from: Friday 30th of July 2010 – Thursday 5th of August 2010 Gallery Opening Hours: Fri, Mon, Tues, Wed: 11.00 am to 6.30 pm
Environmental Message Testing Service Enters Private Beta
Water Words That Work, LLC is accepting requests from nature protection and pollution control organizations to participate in the beta testing round of the Due Diligence Test Panel, our new environmental message testing service. Water Words That Work, LLC is developing the service to help our clients develop more compelling marketing materials to support their fundraising, issue advocacy, and environmental awareness activities. "Environmental scientists, engineers, attorneys, and other professionals often struggle